Russia’s sole aircraft carrier, Admiral Kuznetsov, is notorious for its numerous technical problems, including engine failures, costly repairs, and a constant emission of black smoke. The ship runs on Mazut, a heavy, tar-like fuel that requires complex heating and pressurization.
Summary and Key Points: Russia’s sole aircraft carrier, Admiral Kuznetsov, is notorious for its numerous technical problems, including engine failures, costly repairs, and a constant emission of black smoke. The ship runs on Mazut, a heavy, tar-like fuel that requires complex heating and pressurization.
-The Soviet-era vessel, launched in 1985, suffers from poor-quality piping and boilers, leading to frequent breakdowns and reduced operational capacity.
-This outdated fuel and propulsion system results in significant environmental and health hazards and embarrassing operational failures, such as the need for tugboat assistance.
The Black Smoke of Admiral Kuznetsov: A Symbol of Soviet-Era Engineering
Russia’s lone aircraft carrier, the Admiral Kuznetsov, is internationally recognized for all the wrong reasons: engine failures, costly repairs, a deadly fire, and especially, a constantly spewing, putrid smoke.
Russia’s Only Aircraft Carrier Is a Smoky Mess
Russia’s Kuznetsov runs on a goopy, tar-like substance called Mazut. Sailors regard Mazut as a noxious, sticky nuisance–nearly impossible to remove from clothing.
A heavy petro-chemical, Mazut was the standard fuel for military and commercial vessels through the 1970s, mostly because the sludge’s thick viscosity gave it a high volume to energy ratio relative to lighter distillates. Yet, Mazut had numerous drawbacks, which is why most new ships were installed with nuclear or gas turbine propulsion systems.
Not the Kuznetsov, however, which the Soviet Union launched in 1985 – nearly two decades after the industry pivoted away from Mazut.
Today, the Kuznetsov serves as a belching reminder of why that pivot occurred.
Mazut would be considered a Bunker B or Bunker C fuel. Bunker fuels, which is a colloquial term for the fuel oil that marine vessels use, are divided into A, B, or C classifications, based on their boiling points, carbon-chain lengths, and viscosities.
A is the highest quality classification. C is the lowest. Lower quality fuel emissions, like Mazut’s, typically produce large amounts of sulfur and have negative effects on the environment and human health.
Burning Mazut is complicated. The fuel must be preheated and pressurized using an intricate system of boilers and pipes. So naturally, when using Mazut, properly functioning boilers and pipes are absolutely vital.
The Soviets, however, installed low-quality pipes in the Kuznetsov, setting the ship up for a service life of failure. With shoddy piping, the Kuznetsov is not able to operate all of its boilers at full capacity, all the time.
In fact, the boilers often break down, leaving the ship’s operators to alternate between the functioning boilers. Sometimes, the ship is reduced to using just one boiler, which allows for travel at a glacial 4 knots. Tugboats are often sent to accompany the underpowered and unreliable Kuznetsov.
Actually, in 2012, after returning from the coast of Syria, the Kuznetsov lost power entirely – likely due to boiler failure – and had to be dragged home behind the Russian tugboat Nikolay Chiker. Humiliatingly, the Kusnetsov required escort for 2,700 miles – a fact Russian tried to conceal from the world.
Another consequence of the Kuznetsov’s low-quality pipe and boiler system: black smoke.
The Kuznetsov’s black smoke is likely the result of improper calibration in the preheating or injection mechanisms. So, the Mazut injected into the combustion chamber may not have had time to combust fully. The result: only partially burned Mazut is being released into the atmosphere – in the form of black smoke.
Russia regularly downplays Kusnetsov’s smoking problem. Russian Admiral Ivan Vasilyev, for example, claimed the black smoke was deliberately created, in adherence to maritime tradition, to announce the Russian’s presence.
Why Make a Mazut Aircraft Carrier?
Why Russia created a Mazut-consuming aircraft carrier, in the 1980s, while nuclear and gas turbine options were available, is something of a mystery.
US aircraft carriers, constructed at the same time, relied exclusively on nuclear power. As a result, only crew endurance and supplies limit the US fleets ability to operate. There are no boiler issues, no black smoke, and certainly no tugboats involved.
